“Asbestos of the Sky” – The Aviation Industry’s Darkest Coverup
97 shares
In Brief
The
aviation industry hangs its hat on air travel being “the safest way to
travel.” The truth, however, is that it has harbored a dark secret since
its inception: it’s poisoning its passengers and crew due to deeply
flawed aircraft design, de-prioritizing safety in favor of profit.
In flight, every crew member and
passenger relies on an air supply. The assumption, of course, is that
this air is filtered if not fresh. Perhaps you have sensed (and promptly
dismissed) that there may be quality control issues around cabin air.
The problem goes further than that, however, and astoundingly, this is not by accident but by design.
What’s more concerning is the
fact that the industry has known about this completely preventable
health hazard for at least 40 years, but no attempts have been made to
filter this cocktail of hundreds of chemicals (including
organophosphates in the same category as toxic nerve agents like Sarin)
out of the cabin air before travelers are forced to breath them in. Nor
has the root cause of the problem — unsafe aircraft design and the
deprioritization of human safety — been effectively addressed.
A history of cabin air supply
Essentially, the problem comes
from the need to supply the jet airliners with warm compressed air
while flying at high altitudes. In order to do so, all planes used by
commercial airlines since 1963 inject the cabin with air directly from
the compressors of their jet engines in what is known as ‘bleed air.’ In
the 50’s, engineers designed airplanes which pulled fresh air into the
cabin, but this “modification” was deemed too costly by decision-makers
at the time. As a result of poor design, every breath that the crew and
passengers take today, consists of a 50/50 mix of recirculated cabin air
and bleed air, the latter of which can contains a wide range of
synthetic chemicals, such as tricresyl phosphate (TCP or TOCP), an
organophosphate which is highly neurotoxic to humans. In fact, the World
Health Organisation stated in 1990 that “Because of considerable
variation among individuals in sensitivity to TOCP, it is not possible
to establish a safe level of exposure” and “TOCP are therefore
considered major hazards to human health.”1
And so, with the exception of single aircraft — the new Boeing 787,
where cabin air is taken directly from the atmosphere with electrically
powered compressors — all flights today involve a high risk of exposure
to these neurotoxic chemicals. When you consider there are about
100,000 flights a day (only 5% of which occur on “safe” Boeing 787’s,
with at least 1 in 100 flights experiencing a major ‘fume event,’ this
amounts to the health endangerment of millions of daily passengers. Entire advocacy organizations exist
which are dedicated to exposing the truth about the dangers of toxic
airplane air, and pressuring the industry to initiate reform.
One such group Aerotoxic Association, discusses the bleed air problem in greater detail on its website:
“Bleed air comes from the compressor section of the jet engine, which has to be lubricated. Jet engines mostly have “wet seals” to keep the oil and air apart, which cannot be 100% effective. Furthermore these seals, like any mechanical component, slowly wear out and their effectiveness gradually declines. This wear can occur more rapidly when the engine is working hard, such as climbing under full throttle. They may also fail suddenly and will then let a significant amount of oil into the very hot compressed bleed air, resulting in fumes and/or smoke entering the cabin. This is known as a “fume event”.There are no filters in the bleed air supply to stop this happening.Note that the oil used to lubricate jet engines is not based on petroleum hydrocarbons, as are lubricants for internal combustion engines used in motor cars, outboard motors, tractors etc. Jet engines operate at much higher temperatures and, therefore, use special synthetic chemicals as oil. They also contain organophosphate additives as antiwear agents and other aromatic hydrocarbons as antioxidants. Some of the oil gets partially decomposed, i.e. chemically altered (‘pyrolysed’) due to the high temperatures in the engine.”
Watch the teaser for the new documentary Unflitered Breathed In – The Truth about Aerotoxic Syndrome:
Purchase access to the full film here [not an affiliate link]
A complex toxicological assault
Since at least 1977, with the
first documented case of a C-130 Hercules navigator becoming
incapacitated after breathing contaminated cabin air, the aviation
industry’s secret has remained hidden…
One thing that has worked in
their favor is the common belief that the fatigue, malaise, and similar
complaints experienced after a flight are caused by “jet lag”;
presumably solely a byproduct of ‘disrupted circadian rhythms,’
(medically referred to as desynchronosis) and not the 800lb gorilla of
neurotoxic organophosphate exposures sitting next to every passenger on
each flight.
This is not to say alterations
in bodily rhythms and other ‘natural’ factors like cosmic radiation,
dehydration, and the fact that the cabin is pressurized at between
6,000-8,000 feet (which keeps oxygen levels dangerously low), do not
play a significant role. They certainly do. But the problem is that the
chemical exposures are rarely if ever identified as a problem. When you
also figure in the routine use of pesticides in planes, and the
subsequent “toxic soup” of hydrocarbons and synthetic chemicals created,
the toxicological synergy amplifies the exposure problem far beyond
what would be expected if one focuses only on one chemical.
One can only imagine the
cumulative role these exposures have had on the notoriously poor health
of airline crew, as well. Clearly, there are highly practical
justifications for the industry “cover-up,” as the legal liability for
the damage already done to the health and well-being of aircrew alone
would be astronomical.
What are the symptoms of aerotoxicosis?
In October 2000, the truth started to emerge with the publication of a seminal study titled, “Aerotoxic Syndrome: Adverse health effects following exposure to jet oil mist during commercial flights,”
authored by Dr Harry Hoffman, Professor Chris Winder and Jean
Christophe Balouet, Ph.D . In the study, the researchers introduce
aerotoxic syndrome as a newly identified occupational health condition.
They focused on 10 case reports of airline crew who experienced a
so-called “fume event,” and subsequent health problems.
The following basic symptoms were identified following single or short term exposures:
“Blurred or tunnel vision, disorientation, memory impairment, shaking and tremors, nausea/vomiting, paresthesias, loss of balance and vertigo, seizures, loss of consciousness, headache, lightheadedness, dizziness, confusion and feeling intoxicated, breathing difficulties (shortness of breath, tightness in chest, respiratory failure), increased heart rate and palpitations, nystagmus, irritation (eyes, nose and upper airways).”
Symptoms from long term low level exposure or residual symptoms from short term exposures include:
“memory impairment, forgetfulness, lack of coordination, nausea/vomiting, diarrhoea, respiratory problems, chest pain, severe headaches, dizziness and feeling intoxicated, weakness and fatigue (leading to chronic fatigue), exhaustion, increased heart rate and palpitations, numbness (fingers, lips, limbs), hot flashes, joint pain, muscle weakness and pain, salivation, irritation (eyes, nose and upper airways), skin itching and rashes, skin blisters (on uncovered body parts), signs of immunosupression, hair loss, chemical sensitivity leading to acquired or multiple chemical sensitivity.”
Clearly, if these symptoms are
indeed caused by exposure to “bleed air,” or exaggerated ‘fume events,’
these chemicals have the ability to cause profound damage to the human
body, particularly the nervous and immune systems.
A 40-Year Long Cover Up Now Exposed
Considering aircraft pilots are continually exposed to jet engine chemicals that can even be found in their blood, the industry lacks any reasonable justification for continuing to ignore the problem. Compromising the neurological fitness of pilots should be taken as seriously as a mechanical defect in the plane. Pilots, after all, are essential to keeping the plane safely in the air.
And significant exposures are not a rare occurrence. A 2007 report by the UK Committee on Toxicity of Chemicals in Food, Consumer Products and the Environment (COT) accepts
that fume events occur on 1 flight in 100. The Aerotoxic Association
offers a qualification of this statistic, indicating the problem is
likely even worse: “However, on some aircraft types crews report that
they experience fumes to some degree on every flight and as the
definition of “fume event” is not agreed upon, it makes it impossible to
give a true figure.”
Under-reporting is epidemic,
due to the fact that modern jet aircraft have no chemical sensors
installed, and only visible smoke is officially reported in the flight
log. Technically, the noses of aircrew are the only detectors being
used, and background levels of contamination may not be detectable by
smell at all. Likely the most toxic of the hundreds of chemicals present
in the bleed air, the organophosphate TCOP, in fact, is odorless. It’s a
sad fact, but a U.S. Attorney Alisa Brodkowitz and aerotoxic syndrome
expert once correctly opined:
“…the only thing filtering this toxic soup out of the cabin are the lungs of the passenger and crew.”
60-minutes obtained an internal memo from the Boeing aircraft company dated 2007 [watch minute 13:00 of the 60 minutes episode below].
It’s all about toxic air. Excerpts from the report written by a
frustrated senior Boeing inspector reveal a well recognized problem
within the company:
“Some of the events have been significant, in that the crew reported blue smoke with defined waves in smoke.”“Who knows what the by-products are in hot synthetic turbine oil? The data sheet has warnings about breathing the fumes.”
60 minutes describes the most
startling passage, which “ends on a chilling note. That lives need to be
lost before Boeing will act.”:
That tombstone, unfortunately, already exists. Richard Westgate, British Airlines pilot, died at 43 after constantly being exposed to fume events. Doubtlessly, many other aircrew and passengers have suffered a similar fate.
Want Things To Change? It’s Up To You and Me
As we mentioned above, the
only exception is Boeing’s new 787, a long haul aircraft serving
non-stop, inter-continental travel, with few exceptions. [see list of routes] [another website that keeps track of routes]
Not surprisingly, Boeing does not feature the “clean air” design of
these planes in its marketing copy. Bringing attention to this feature
would also bring attention to the widespread problem, which all of its
other aircraft participate in. Despite this, advocacy organizations
have publicly congratulated Boeing on its decision to create a non-toxic
alternative. For instance, in 2014, The Global Cabin Air Quality
Executive (GCAQE) which represents more than 800,000 airline staff and
consumers, put out a press release titled, “Only The Boeing 787 Provides Passengers And Crews With Clean Breathing Air.”
The development and existence
of the Boeing 787 represents a tacit acknowledgment of the industry wide
problem discussed in this article, and is a wonderful step towards a
permanent solution. But the vast majority of planes are still in the
technological dark ages, with awareness of the extent of the problem and
danger only starting to trickle into consciousness.
It will be consumers and
non-governmental advocacy organizations that will force the industry and
its regulators to make this issue a priority. If only one airline in
this country made the step of addressing the problem, it would see huge
support by an increasingly educated consumer base [that’s you and who
you share this article with!]
Short of redesigning existing aircraft, the following solutions, offered by the Aerotoxic Association, could also be implemented:
-
As bleed air is not presently filtered, installation of bleed air filtration systems would eliminate the problem, although a technically efficient system does not yet seem to have been developed.
-
A less toxic oil formulation could lead to significant improvement. The French oil company NYCO is continuously developing such oils.
-
Chemical sensors to detect contaminated air in the bleed air supplies – instead of human noses – would alert pilots to problems, allowing prompt preventive action.
As discussed in the conclusion
of the seminal paper on aerotoxic syndrome referenced above, the
aviation industry is reluctant to acknowledge the problem and reform:
“It has become apparent that
the primary safety consideration of the airlines is to keep airplanes
flying – the safety of workers appears to have a very low priority to
operational safety. Further, the regulatory agency involved in aviation
safety (the Civil Aviation Safety Authority) admitted in evidence to the
Senate Aviation Inquiry that its area of responsibility is airplane
safety, not occupational health and safety.
Monitoring studies conducted by aircraft manufacturers and the airlines have failed to detect any major contaminants, although to date most monitoring studies have used inappropriate sampling techniques (such as air collection of poorly volatile contaminants) or inadequate methodologies (such as sample collection time, sample volume, storage of samples, not taking account of altitude). No monitoring has been conducted during a leak incidentAttempts by airlines to address this problem through design, maintenance and operational improvements and through staff support and medical care have not been successful, and in the main, continue to be reactive and piecemeal. Obviously, in some cases, options such as improving engine design are not within the sphere of activity of the operators. The efficacy of recent modifications to the aircraft remains unknown, and leaks are still occurring, albeit at a reduced rate.An admission was grudgingly made by one airline in 1998 that adverse exposures had been occurring, and that such exposures might cause irritation and transient effects. However, the development of long term symptoms is vigorously denied.Civil aviation regulations clearly state that “the ventilation system must be designed to provide a sufficient amount of uncontaminated air to enable the crew members to perform their duties without undue discomfort or fatigue and to provide reasonable passenger comfort.” The admission that irritation and transient symptoms can occur demonstrates non-compliance with the above rules.Further, the adversarial and acrimonious manner in which some airlines have pursued workers compensation cases brought by staff with aerotoxic syndrome indicates a confrontational approach which is unlikely to be beneficial to all parties in the long term.”
The good news is the internet,
social media, and consumer-driven platforms like ours have demonstrated
how we can all engage the system to change the world. Join our online movement by subscribing to our newsletter if you haven’t already.
First, watch the new documentary on aerotoxic syndrome: UNFILTERED BREATHED IN – The Truth about Aerotoxic Syndrome.
Second, if you are a Facebook user, join the group Angel Fleet, which has almost 9,000 members discussing the problem, and working on solutions together.
Third, get yourself a mask
with the capability to greatly mitigate exposures in the case of a leak
or “fume event.” This is a relatively affordable one with a charcoal
filter that we are presently investigating directly from the Aerotoxic Association website. [not an affiliate link] They will ship to the United States; you can caculate the cost when you put it in your basket.
[Note: we have not yet had the
opportunity to extensively evaluate the different masks on the market,
but will be following up with a research report once we get better
inform you. This will also include strategies to mitigate toxicity].
Four, please share this article help spread the word and change the world with us together.
Additional References:
Additional Resources:
Downloadable information for your health care provider funded by the FAA:
- Medical protocol for HCP 2008 93.02 Kb
- TFA Aerotoxic syndrome handout for passengers
- TFA Aerotoxic syndrome handout for crew
Sayer Ji is founder of Greenmedinfo.com, a reviewer at the International Journal of Human Nutrition and Functional Medicine, Co-founder and CEO of Systome Biomed, Vice Chairman of the Board of the National Health Federation, Steering Committee Member of the Global Non-GMO Foundation.
If you want to learn more from Greenmedinfo, sign up for their newsletter here.
Help Support Collective Evolution
In order to stay truly independent, we need your help. We are not going to put up paywalls on this website, as we want to get our info out far and wide. For as little as $3 a month, you can help keep CE alive!
SUPPORT CE HERE!
Thanks a lot for this post. Very important points are mentioned in this post. Asbestos work place is very dangerous. You have to wear respiratory safety equipment otherwise it can cause lot of health issues and even cancer. We deal in Asbestos Safety Signs and we know the health hazard asbestos can cause.
ReplyDelete